Putting Glass Walls on South Carolina Slaughterhouses So We Can See Behind Closed Doors from FAUN Friends Of Animals United
Brown Packing Co., Inc.

Address: 116 Willis St. Gaffney, SC 29340
Establishment No.: m1085

USDA Inspection Report: 21 Nov 2011

Code: 03J03
Violation: 417.3(a)(4), 417.2(c)(4)

Citation: Approximately 1604 hours the following non com pl iance was observed while performing Zero Tolerance Verification. Carcass 11 of lot 3715 was identified with green fecal located approximately 1/2, inch of rounds surface. Production briefly stopped; [redacted] was notified and shown non compliance. [redacted] railed carcass onto re-work station for further examination by IIC. Necessary measures were taken as stated in establishments HACCP Plan, should Zero Tolerance failure occur.1606 hours green fecal with rough texture was identified on carcass 14 of lot 3715 on upper leg surface. The fecal was approximately 1/4 of an inch of legs surface. Production briefly stopped; [redacted] was notified and shown non compliance. [redacted] railed the carcass onto re-work station for further exam ination by IIC. Necessary measures were taken as stated in establishments HACCP Plan, should Zero Tolerance failure occur.1608 hours carcass 17 failed Zero Tolerance Verification due to X of an inch of green fecal found on rounds surface. was notified and shown non compliance. [redacted] railed carcass onto out rail station for further examination by II C. Necessary measu res were taken as stated in establishments HACCP Plan.1610 hou rs carcass 19 failed Zero Tolerance Verification due to fecal identified on upper legs surface. The fecal was dark brown with rough texture covering approximately 1/2 inch of legs surface. [redacted] was notified and shown non compliance. [redacted] agreed this was fecal, necessary measures were taken as stated in establishments HACCP Plan. 1614 hours carcass 23 of lot 3715 failed Zero Tolerance Verification due to green fecal identified on lower half of carcass leg. The fecal covered approximately 2 inches of lower leg surface. [redacted] was notified and shown non compliance. [redacted] trimmed contaminated surface; necessary measures weretaken as stated in establishments HACCP Plan. No preventive measures were given at the time of events. Management notified IIC that all prior carcasses being held at the re-work station for h is examination were documented as feca l fail ure. All carcasses were trimmed and released. This document serves as written notification that your establishment failed to comply with FSIS regulatory requirements cited above. Last similar NR RSA1916112321 dated 11/21.2011.

Regulation:

417.3(a)(4) No product that is injurious to health or otherwise adulterated as a result of the deviation enters commerce.

417.2(c)(4) List the procedures, and the frequency with which those procedures will be performed, that will be used to monitor each of the critical control points to ensure compliance with the critical limits

Next Report: USDA Inspection Report: 22 Nov 2011
Previous Report: USDA Inspection Report: 19 Nov 2011

Return to: Brown Packing Co., Inc.
Return to: South Carolina Slaughterhouses
Return to: Slaughterhouses