M.B. Consultant Ltd.
Putting Glass Walls on Slaughterhouses So We Can See Behind Closed Doors from FAUN Friends Of Animals United

Address: 5190 Main St, South Fallsburg, NY 12779
Establishment No.: p18414

USDA Inspection Report: 21 Jul 2010

Code: 03C01
Violation:  417.4(a)(2)(ii)

Citation: At approximately 1930 hours, while performing the review and observation component of an unscheduled 03C01 procedure task I observed the following; a deviation from the critical limit for CCP# 6 (Chiller EO Water Monitoring) during the designated Quality Control's monitoring of the residual free chlorine level to [redacted] using a calibrated colorimeter. The deviation observed resulted in a reading from the colorimeter , specifically [redacted]. Two additional residual free chlorine concentration samples were taken immediately resulting in colorimeter readings of [redacted] ppm and [redacted] ppm. I observed the designated Quality Control take immediate corrective actions and perform additional residual free chlorine concentration samples after the immediate corrective actions were taken which resulted in a colorimeter reading of and , respectively. During the observance of Quality Control performing the Corrective Actions I observed no direct observation performed by QAS Personnel or designee of the Corrective Actions taken by QC during the occurrence of the deviation from the critical limit for CCP#6. The establishments Raw Not Ground HACCP plan signed and dated 4/4/10, page 3, section titled Corrective Actions states: "[redacted] " and on page 3, section titled Verification states: "[redacted]. QC Technician, was verbally notified immediately of the non-compliance. This is a failure to meet 9CFR 417.4(a)(2)(ii). This document serves as written notification that your failure to comply with regulatory requirement(s) could result in additional regulatory or administrative action.

Regulation:

417.4(a)(2)(ii) Direct observations of monitoring activities and corrective actions

 

Next Report: USDA Inspection Report: 21 Jul 2010
Previous Report: USDA Inspection Report: 16 Jul 2010

Return to: M.B. Consultant Ltd
Return to: New York Slaughterhouses
Return to: Slaughterhouses